Сущность действи предлагаемого прибора заключаетс в том, что по испытуемой краске, нанесенной на медленно и непрерывно движущуюс ленту, свободно вращаетс металлический ребристый (дисковый) валик. Ребра-выступы валика, соприкаса сь со свежей краской, снимают ее с ленты, оставл на последней прозрачный след. Это длитс до тех пор, пока на слое краски не образуетс прочна пленка. Длина следа пропорциональна времени пленкообразовани (обратно пропорциональна скорости процесса). Вращение ленте сообщает часовой механизм с посто нной скоростью 1 ммМин. Ребристый залик вращаетс вследствие трени о ленту с краской с такой же скоростью.The essence of the operation of the proposed device lies in the fact that the metal ribbed (disk) roller freely rotates along the test paint applied on a slowly and continuously moving tape. The ribs of the roller, contacting with fresh paint, remove it from the tape, leaving a last transparent trace. This lasts until a durable film is formed on the paint layer. The length of the trace is proportional to the time of film formation (inversely proportional to the speed of the process). Rotation of the tape imparts a clock mechanism at a constant speed of 1 mmMin. The ribbed edge rotates as a result of rubbing the paint tape at the same speed.
На фиг. 1 изображен вид прибора сбоку; па фиг. 2 - вид его в плане с частичным разрезом.FIG. 1 shows a side view of the device; pas figs. 2 - a view of it in plan with a partial cut.
Прибор состоит из металлических валиков В и fii, лежащих па опорах в одной горизонтальной плоскости. На валики нат нута бесконечна лента а из целлофановой пленки, нат гиваема пружиной д. Один из валиков соединен с часовым механизмом и приводитс , им во вращеиие. На этом валике поверх пленки свободно лежит ребристый (дискозы)) валик Б. При работе часового механизма вместе с н11Ж11км валихом В вращаетс и бескоиечна лента. Дисковьи валик Б, прижаты; собственным весом к ленте а, вращаетс при этом вокруг своей оси, вследствие фрикционного контакта с лентой. Если на леиту предварителы;о нанести тонким слоем краску, то ребра или диски валика В, прокатыва сь по ленте, будут оставл ть след на свежем слое краски в виде лрозрачной полоски на пленке (краска будет прилипать .к ребра.лт валика ). Как только начинает образовыватьс пленка на краске (по мере ее высыхани ), след становитс все менее заметным, иока, наконец, не исчезнет совсем.The device consists of metal rollers B and fii, which lie on supports in the same horizontal plane. On the tension rollers there is an endless ribbon of cellophane film, tensioned by a spring, e. One of the rollers is connected to the clockwork and is driven by it in rotation. On this roller, a ribbed (diskose)) rolls freely on top of the film B. When the clock mechanism is in operation, the needleless tape is rotated along with the roller N1111km of the roller B. Disc roller, pressed; with its own weight to the belt a, it rotates around its axis, due to frictional contact with the belt. If the pretreatment of the leite is applied with a thin layer of paint, the edges or disks of the roller B, rolling over the tape, will leave a mark on the fresh layer of paint in the form of a transparent strip on the film (the paint will adhere to the edges of the roller). As soon as a film begins to form on the paint (as it dries out), the trace becomes less noticeable, and finally, iok will not disappear completely.
Длина прозрачной полоски (следа), как выше указывалось, обратно пропорциональна скорости пленкообразовани .The length of the transparent strip (trace), as indicated above, is inversely proportional to the speed of film formation.
Нанесение краски на леиту осуществл етс в самом приборе. Дл этого вместо валика .6 устанавливаетс специальный массный валик г с посто нным объемом испытуемой краски (краска иредварительио раскатываетс валиком на плите).The paint is applied to the cast resin in the instrument itself. For this, instead of the roller .6, a special mass roller r is installed with a constant volume of the test paint (the paint and the medium are rolled by a roller on the slab).