Одной из главных операций при ремонте электрических газоанализаторов следует считать изготовление новых плеч мостика Уитстона с последующим подбором их сопротивлений . Последние изготовл ютс из чистых платиновых проволок диаметром 0,04 мм и длиной 90 мм, к концам которых припаивают золотом платино-иридиевые спирали, которые, в свою очередь, припаиваютс к никелевым стерженькам. Таких нитейплеч в газоанализаторе четыре. Особое внимание при изготовлении новых нитей должно быть обращено на отмеривание точной длины проволок и качество пайки. Это одна из самых трудоемких операций при ремонте. После изготовлени плеч приступают к подбору их сопротивлений. Обычно дл этого примен етс специальное приспособление, описанное в журнале ,Точна Индустри № 1 за 1932 г. Оно схематически изображено на фиг. 1 прилагаемого чертежа. На дерев нной доска укреплены четыре стойки В, имеющие во взаимно перпендикул рном направлении сквозные отверсти , куда вставл ютс никелевые стерженьки с припа нными к нимOne of the main operations in the repair of electric gas analyzers should be the manufacture of new arms of the Wheatstone bridge, followed by the selection of their resistances. The latter are made of pure platinum wires with a diameter of 0.04 mm and a length of 90 mm, to the ends of which platinum-iridium spirals are soldered with gold, which, in turn, are soldered to nickel rods. There are four such gas tapes in the gas analyzer. Particular attention in the manufacture of new threads should be paid to the measurement of the exact length of the wires and the quality of soldering. This is one of the most labor-intensive operations in the repair. After the shoulders are fabricated, they start selecting their resistances. Typically, this is done using a special fixture, described in the journal, Precise Industry No. 1, 1932. It is schematically depicted in FIG. 1 of the attached drawing. On the wooden board, four pillars B are fastened, having through-holes in the mutually perpendicular direction, into which nickel rods with soldered to them are inserted.
платиновыми проволоками. Последние зажимаютс дл обеспечени контакта винтами. Цифрами JO обозначены зажимы дл присоединени гальванометра и аккумул торной батареи А (фиг. 2). Вс установка сверху закрываетс стекл нным колпаком. На фиг. 2 изображена схема электрических соединений устройства, представл юща мостик Уитстона. Здесь а, Ь, с, d обозначают платиновые нити, G-гальванометр, А-аккумул торную батарею, 8-реостат, 7-миллиамперметр . Включив ток и подрегулировав реостатом его силу по миллиамперметру 7, наблюдают за показанием стрелки гальванометра G. Если последн при этом остаетс в состо нии поко (на нуле), то сопротивлени нитей подобраны правильно и могут быть монтированы в газоанализаторе. Обычно равновесие мостика отсутствует и приходитс либо мен ть его плечи местами, либо заменить одну из нитей новой. Подбор нитей, с целью уравновешивани мостика, занимает много времени вследствие колебаний стрелки гальванометра, которые происход т беспрерывно. Судить о точном равновесии или остепени неравно10platinum wires. The latter are clamped to ensure contact with the screws. JO numbers denote clamps for connecting a galvanometer and battery A (Fig. 2). The entire top installation is closed with a glass bell. FIG. Figure 2 shows a circuit diagram of the electrical connections of the device, representing the Wheatstone bridge. Here, a, b, c, d denote platinum filaments, a G-galvanometer, an A-battery, an 8-rheostat, a 7-milliammeter. Turning on the current and adjusting the rheostat with its force on a milliammeter 7, observe the reading of the arrow of the galvanometer G. If the latter remains at rest (at zero), the resistance of the filaments are selected correctly and can be mounted in the gas analyzer. Usually there is no equilibrium of the bridge and it is necessary either to change its shoulders in places, or to replace one of the threads with a new one. The selection of threads, in order to balance the bridge, takes a long time due to oscillations of the arrow of the galvanometer, which occur continuously. Judge exact balance or degree unequal
фиг.FIG.
1й1st
iHii. „Печатный Труд, оак. 3607-7WiHii. „Printed Labor, oak. 3607-7W